SaturnFans.com
saturnfans.com - classifieds - forums - webmail


Go Back   SaturnFans.com Forums > Search Forums

Showing results 1 to 25 of 500
Search took 1.84 seconds.
Search: Posts Made By: billr
Forum: S-Series Tech 06-18-2021, 12:04 PM
Replies: 3
Views: 41
Posted By billr
Re: 2002 SC2 serpentine belt too tight?

Oh, I see the OP is another one of us dummies that can't change a serp belt in under 5 minutes... welcome to the club!

Do you still have the old belt to compare length to? Have any pulleys been...
Forum: S-Series Tech 06-17-2021, 04:28 PM
Replies: 20
Views: 373
Posted By billr
Re: P0733 2002 sl2

When I bought my '97 Chevy van I got an all-inclusive 10 yr/100k mile warranty for $980. The deal was that I would get that $980 back at the end (which I did) if no claims were made. So, it cost me...
Forum: S-Series Tech 06-14-2021, 09:31 PM
Replies: 9
Views: 177
Posted By billr
Re: 2001 SC2 power window issue

Does an ohmmeter confirm that the switch still doesn't make connection when it is operated? Post a picture of what the switch looks like as disassembled for cleaning, so we can inspect the condition...
Forum: S-Series Tech 06-14-2021, 05:38 PM
Replies: 9
Views: 177
Posted By billr
Re: 2001 SC2 power window issue

Are you sure it is an electrical problem, and not jamming of the mechanism?
Forum: S-Series Tech 06-14-2021, 12:53 PM
Replies: 5
Views: 80
Posted By billr
Re: Rear Subframe trailing arm rot.

I'm pretty sure the rear is non-removable.
Forum: S-Series Tech 06-13-2021, 03:45 PM
Replies: 2
Views: 56
Posted By billr
Re: A/C Clutch vs Compressor

The refrigerant pressure should be approximately equal to its temperature in degrees F, when the compressor is not running. You can check at either the high or low port, they will read the same when...
Forum: S-Series Tech 06-11-2021, 03:22 PM
Replies: 4
Views: 116
Posted By billr
Re: batt post and jumpstarting

Has somebody modified/replaced the battery cables? The stock side-terminals are easy to clip onto. Maybe post a picture of the terminals and you charger/jump-start clips.

As far as jump-starting...
Forum: S-Series Tech 06-09-2021, 06:11 PM
Replies: 3
Views: 139
Posted By billr
Re: 1999 Saturn SW-2 Ignition Module???

It could be the wiring to the ICM. R & R the harness connectors to the ICM and try again. Just "wiping" those connector contacts may heal it. No Joy? Then back-probe the drive signals to the two...
Forum: S-Series Tech 06-09-2021, 03:57 PM
Replies: 21
Views: 292
Posted By billr
Re: Diagnosing A/C (again)

The problem you describe is only one type that I have found with the service ports. Most couplers on gauge hoses have a shut-off valve in the couplers, for "capping off" the hose ends and preventing...
Forum: S-Series Tech 06-08-2021, 10:13 PM
Replies: 21
Views: 292
Posted By billr
Re: Diagnosing A/C (again)

There is no need to turn the compressor to fill the system. There will be enough transfer between the high and low side through the expansion valve/orifice and through compressor vane seals to...
Forum: S-Series Tech 06-08-2021, 06:50 PM
Replies: 5
Views: 142
Posted By billr
Re: P0420 and smoke

No, the S2 does not control AFR at all. It is there only to verify the cat is working OK. When you get that P0420 either the S2 sensor/circuit is bad, or the cat is bad.

Live-data can be had for...
Forum: S-Series Tech 06-08-2021, 12:34 PM
Replies: 5
Views: 142
Posted By billr
Re: P0420 and smoke

No, the P0420 is probably not from the S1 or fuel trims. Could be a bad S2, though.

What color smoke, white grey, or black?

Use live-data to check out the O2 sensors and fuel trims, why guess?...
Forum: S-Series Tech 06-07-2021, 11:54 PM
Replies: 21
Views: 292
Posted By billr
Re: Diagnosing A/C (again)

I gotta ask... have you given in and used a UV light during your "looking" for leaks?
Forum: S-Series Tech 06-06-2021, 11:35 AM
Replies: 21
Views: 292
Posted By billr
Re: Diagnosing A/C (again)

Try the UV light anyway, looking for leaks. There is probably some dye left over from original charge, as well as external dye marks from previous leaks that could give some clues.

This being a...
Forum: S-Series Tech 06-05-2021, 09:01 PM
Replies: 21
Views: 292
Posted By billr
Re: Diagnosing A/C (again)

"Some searching turned up these two wiring diagrams for 3rd gen S-series ac systems.
Attached Images
File Type: jpg 02 ac wiring.jpg (191.6 KB, 3 views)
File Type: jpg 01 ac wiring.jpg (185.7 KB,...
Forum: S-Series Tech 06-02-2021, 11:12 AM
Replies: 7
Views: 197
Posted By billr
Re: computer for 97 SL1

"Does this mean a custom programming could also be done, one not emissions focused but rather focusing on maximum MPG or horsepower?"

No, I was referring to a place that will program to any OEM...
Forum: S-Series Tech 05-31-2021, 02:47 PM
Replies: 14
Views: 252
Posted By billr
Re: Radiator Fan Linked to A/C?

Did you buy that Pontiac brand-new, from the dealer? I think that wiring had been modified, no manufacturer would design/build engine cooling like that.
Forum: S-Series Tech 05-31-2021, 01:21 PM
Replies: 14
Views: 252
Posted By billr
Re: Radiator Fan Linked to A/C?

The radiator fan should come on when either the engine temp is hot enough (about 210F) or the A/C is selected to be on (at any temp).

I forget what year your car is, but the fan will also come on...
Forum: S-Series Tech 05-30-2021, 07:05 PM
Replies: 11
Views: 337
Posted By billr
Re: Sl1 trans shift trouble after rebuild

Once control of LP is changed, as would have happened if that solenoid was bad, then the shift parameters have to be "relearned" by the PCM. That will happen automatically with just a bit of driving.
Forum: S-Series Tech 05-29-2021, 01:13 PM
Replies: 10
Views: 293
Posted By billr
Re: AC how much PAG oil should come OUT of a compressor when pulled?

I only know about my '94. The high was/is an O-ring; but the low was a "D"-ring that did not go into the bore on the compressor far enough to give a reliable seal, I think.

It went back together...
Forum: S-Series Tech 05-28-2021, 11:45 PM
Replies: 10
Views: 293
Posted By billr
Re: AC how much PAG oil should come OUT of a compressor when pulled?

I feel that method outlined above, "measure what you drain and replace the same" is inadequate. It doesn't account for any oil that may have been lost to leakage or discharge of the refrigerant.
...
Forum: S-Series Tech 05-28-2021, 08:04 PM
Replies: 13
Views: 242
Posted By billr
Re: 2000 sl airconditioner question

I'll bow out here. I don't have a gen3 electrical schematic available, so can't follow along as you dig deeper into this.
Forum: S-Series Tech 05-28-2021, 01:05 PM
Replies: 13
Views: 242
Posted By billr
Re: 2000 sl airconditioner question

"Even with the diode removed, with good fuse, doesn't work"

Maybe I interpreted that wrong. I thought "doesn't work" meant the fuse blew again. Not so, huh?

The fuse did not blow again when...
Forum: S-Series Tech 05-28-2021, 11:30 AM
Replies: 13
Views: 242
Posted By billr
Re: 2000 sl airconditioner question

OK, with the compressor disconnected from the car harness, and the diode out, does the fuse still blow if you try selecting A/C?
Forum: S-Series Tech 05-28-2021, 11:27 AM
Replies: 4
Views: 145
Posted By billr
Re: 2000 SL2 Valve Body Swap

Sounds are notoriously hard to describe or even tell which direction they are really coming from. Do these two sounds, the clack that is always there, and the ratcheting only when hot, happen when...
Showing results 1 to 25 of 500

 
Forum Jump

All times are GMT -4. The time now is 01:43 AM.

Advanced Forum Search | Advanced Photo Search


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2021, vBulletin Solutions Inc.
SaturnFans.com. The Saturn Enthusiasts Site.