|04-26-2014, 11:59 PM||#1|
Join Date: Apr 2014
Can U solve my SC1 MYSTERY
I have a really good 1999 SC1 Mystery. Please solve if you can.
Here are my consistent problems:
1. Starts Cold but not when temp is past 1/4 mark.
2. Code: Multiple Misfires
3. Runs smooth like kitten when cold. When it nears 1/4 temp mark it starts running really rough. Can feel the difference and muffler sound like outboard boat motor.
4. Idles up and down by -300/+300 RPM when near or at the 1/4 temp mark.
5. Will start to overheat when stopped for too long or left in park for awhile.
I have replace the following:
spark plugs, Ignition wires, Fuel pump, fuel filter, Both Ignition Coil Packs, Ignition Control Module, Crankshaft Position Sensor.
I have also cleaned the Throttle body and its sensors. Also cleaned all the injectors. Cleaned the MAP.
|SaturnFans.com Sponsored Links|
|04-27-2014, 12:03 AM||#2|
Join Date: Apr 2008
Location: Far Southwestern Iowa
Re: Can U solve my SC1 MYSTERY
Replace the ECTS and inspect the 2 wires for any splices. If you find any cut them out and properly solder and heat shrink them.
Check the exhaust system for leaks this way.
Exhaust leak check.
--Locate a low pressure high volume air source, reversible vacuum cleaner, large fan, leaf blower or what ever you can find.
--Loosely couple to cold exhaust at the tail pipe, or direct fan at tail pipe.
--Spray every inch of the exhaust between the head and CAT inlet with a mixture of 2 or 3 drops of dish soap and water in a spray bottle.
--Pay close attention to the lower flange, lower support clamp, and flex connector.
--The flex connector is under the protective braid so it requires quite a bit of solution to show any leaks.
If you replaced the OEM fuel filter with anything but a WIX 33731 you will eventually have fuel pressure problems. http://www.rockauto.com is the low cost parts source.
|Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)|
|Thread||Thread Starter||Forum||Replies||Last Post|
|Help Solve Electrical Problem?||kimlou45||General Saturn Discussion||1||07-02-2012 11:06 PM|
|Help me solve my vibration problem please!||Beerme||S-Series General||9||04-15-2009 09:15 PM|
|Very interesting little problem with an sl1... can you solve it?||acr2001||S-Series General||6||10-11-2005 01:32 PM|
|Solve Two Problems in One Thread (Hopefully)||NashvilleRider||S-Series Tech||4||04-19-2005 10:43 PM|