View Single Post
Old 10-18-2013, 04:38 PM   #3
npereza5
Junior Member
npereza5 is on a distinguished road
 
Join Date: Oct 2013
Posts: 23
Default Re: power steering pump question

Found my answer under "power steering" section page 87 of 222. tires comes off. and pulley and blah blah blah. Its copied below in case anyone needs. I will remove the power steering pump when i change the control arm and post back the results if the leak is indeed from the pump.

Power Steering Pump Replacement (LY7)
Callout Component Name
Preliminary Procedures
1. Remove the drive belt. Refer to Drive Belt Replacement .
2. Remove the right front tire and wheel assembly. Refer to Tire and Wheel Removal
and Installation .
3. Remove as much power steering fluid from the remote power steering fluid reservoir
as possible.
4. Place drain pans under the vehicle as needed.
1 Power Steering Fluid Reservoir Outlet Hose Clamp
2 Power Steering Fluid Reservoir Outlet Hose
3
Power Steering Gear Inlet Hose
Procedure:
NOTE:
Refer to Fastener Notice .
2007 Saturn Aura XR
2007 STEERING Power Steering - Aura
POWER STEERING FLUID RESERVOIR REPLACEMENT - OFF VEHICLE (LZ4)
Disassembly Procedure
1. Remove the power steering pump. Refer to Power Steering Pump Replacement (LZ4) or
Power Steering Pump Replacement (LY7).
2. Place the power steering pump on a fixed, flat surface, with the power steering pump shaft
facing upward.
Discard the and install a NEW power steering gear inlet hose O-ring seal
prior to installation of the hose.
Tighten: 27 N.m (20 lb ft)
4
Engine Mount Adapter Bolt
Tighten: 58 N.m (43 lb ft)
5
Power Steering Pump Bolt
Tighten: 50 N.m (37 lb ft)
6
Power Steering Pump
Procedure
1. Remove the power steering pump pulley. Refer to Power Steering
Pump Pulley Replacement (LZ4) or Power Steering Pump Pulley
Replacement (LY7).
2. Remove the engine mount adapter bracket bolts.
3. Remove the engine mount adapter bracket.
4. Fill and bleed the power steering system. Refer to Power Steering
System Bleeding.
npereza5 is offline   Reply With Quote