SaturnFans.com
saturnfans.com - classifieds - forums - webmail


Go Back   SaturnFans.com Forums > Search Forums

Showing results 1 to 25 of 64
Search took 0.28 seconds.
Search: Posts Made By: GTSRider
Forum: Ion General 01-21-2021, 12:57 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

Now Happy to Report Problem, Fixed !
Crank sensor was replaced and synched in by a shop, and that cured my problem 99%..... leaving an occasional minor tendency to stall , without stalling. This...
Forum: Ion General 01-20-2021, 05:37 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

Update....got a shop to synch newly installed Crankshaft Sensor with ECM today, and no codes whatsoever.....engine runs much better under throttle, but still hesitates off idle ..... but only 2 out...
Forum: Ion Tech 01-16-2021, 08:37 PM
Replies: 6
Views: 512
Posted By GTSRider
Re: 7E8 -7E9 Codes

Thanks IM.... you made my weekend.
Will have that done sometime next week.
Forum: Ion Tech 01-16-2021, 05:00 PM
Replies: 6
Views: 512
Posted By GTSRider
Re: 7E8 -7E9 Codes

im..... I replaced crank sensor, and now have code PO315 ....CRANK SENSOR NOT YET LEARNED .... now over 200 miles of work commuting , and engine still stalls and coughs , but not nearly as...
Forum: Ion General 01-13-2021, 05:30 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

Hmmm....like your idea.... will try that soon....thanks...
Forum: Ion General 01-11-2021, 08:01 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

CEL is now on, it wasn't , but now is on, but there are no number codes present... only says, crankshaft sensor/system is not yet learned.
So now have over 100 miles, but have not held it at 3-4,000...
Forum: Ion Mods 01-10-2021, 09:04 PM
Replies: 1
Views: 258
Posted By GTSRider
2.2 to 2.4 Swap

Is a 2.4 a plug and play swap in a 2.2 ION ?
Forum: Ion General 01-10-2021, 07:38 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

No codes...my hand held unit OBD continues to says....
"Crankshaft position sensor not learned "
Do I need to take this to my dealer to have it...
Forum: Ion General 01-10-2021, 12:11 PM
Replies: 18
Views: 1,683
Posted By GTSRider
Re: 2003 ION Stalls at Stop....Now Dangerous to Drive

In my ongoing quest to quell stalling issue... I installed a new crank sensor yesterday 1-9-21.....after 60 miles, of all types of driving, codes now read learning crank sensor....question....how...
Forum: Ion Mods 01-10-2021, 10:21 AM
Replies: 36
Views: 8,487
Posted By GTSRider
Re: 2.2L Tuning who needs it please come in!

Does anyone make a simple bolt on turbo kit for a 2.2 ION ?
Forum: Ion Tech 01-09-2021, 08:13 PM
Replies: 3
Views: 397
Posted By GTSRider
Re: Latest Problem with 03 ION

Thanks Bill....will check that out next time, car is on lift.
.....and report back.
Forum: Ion Tech 01-08-2021, 05:22 PM
Replies: 3
Views: 397
Posted By GTSRider
Re: Latest Problem with 03 ION

Had ION on lift today, inspecting clunking noise coming from rear..... all is solid and tight underneath..... but I think I may know what it is....
it may be the trunk lid banging...
Forum: Ion Tech 01-06-2021, 05:56 PM
Replies: 3
Views: 397
Posted By GTSRider
Latest Problem with 03 ION

This car has been an issue a month for the last 6 years of ownership..... some minor , some time consuming to fix. Parts , I find are cheap for this car, but I do all my repairs myself, so it's more...
Forum: Ion Tech 12-26-2020, 08:10 PM
Replies: 6
Views: 512
Posted By GTSRider
Re: 7E8 -7E9 Codes

Thanks for the response....I think my brother has an in-depth scanner, I can access....but I have had a stalling issue for 6 months now, and feel I have a good hunch what it is... I will replace the...
Forum: Ion Tech 12-26-2020, 03:23 PM
Replies: 6
Views: 512
Posted By GTSRider
7E8 -7E9 Codes

I just went shopping, and in the middle of my trip these codes appeared , I erased them , and the CEL immediately came back on.
Anyone ever have this happen ? What is...
Forum: Ion General 12-23-2020, 01:52 AM
Replies: 3
Views: 566
Posted By GTSRider
Re: High Mileage Ions

I am the second owner of my 2003 ION 4 door, which now has 230,500, but it has had much done in the last 6 years of my ownership.
New Alt,and belt, 2 sets of new front bearings , a set of lower...
Forum: Ion Tech 12-20-2020, 03:34 PM
Replies: 9
Views: 1,297
Posted By GTSRider
Re: 2005 Saturn ION dies while driving and after its little colder it starts again

Hello....curious if you ever solved problem, and what was cause ?
Forum: Ion Tech 12-11-2020, 07:08 PM
Replies: 18
Views: 2,030
Posted By GTSRider
Re: Saturn ION Engine Stalls When Put into Drive

Problem returns....but better than it was....will post again when permanently solved.
Forum: Ion Tech 12-09-2020, 05:47 PM
Replies: 3
Views: 385
Posted By GTSRider
Re: Coolant Temp Sensor

Very Recently....like a week ago, replaced cracked exhaust manifold with new,upstream 02 sensor, new cat and lower sensor, IAC , TPS, MAP, with coolant temp sensor coming, new plugs , new ignition...
Forum: Ion Tech 12-08-2020, 05:10 PM
Replies: 0
Views: 354
Posted By GTSRider
Aisin 5 speed Transmission Filter Change

Has anyone ever installed a Filter kit on a 5 speed Aisin transmission ?
I have a 2003 ION with this transmission with 230,000 miles and changed fluid once at 162,000 miles , when trannie was...
Forum: Ion Tech 12-08-2020, 04:55 PM
Replies: 2
Views: 393
Posted By GTSRider
Re: Leak between manifold and front pipe.

Just did this job the other day....make sure to tighten the 3 studs slowly , and evenly, so you have a flat even seal between all 3.
Forum: Ion Tech 12-08-2020, 04:49 PM
Replies: 3
Views: 385
Posted By GTSRider
Coolant Temp Sensor

I have been battling stalling at stop issue , since August now, and have replaced every sensor , on this 2003 ION but coolant temp sensor , below the exhaust manifold. Friend recommended...
Forum: Ion Tech 11-23-2020, 05:53 PM
Replies: 18
Views: 2,030
Posted By GTSRider
Re: Saturn ION Engine Stalls When Put into Drive

After more than 4 months, I have cured the stalling, on my 03 ION 2.2 .....when put in drive or reverse, which was a potential accident, when happening at lights, and was responsible for a few very...
Forum: Ion Tech 11-17-2020, 07:44 PM
Replies: 4
Views: 460
Posted By GTSRider
Re: Drivers Side Front Turn Signal bulb Out

Thanks....will try the Wagner bulbs....
Pete
Hudson Valley N.Y.
Forum: Ion Tech 11-16-2020, 06:40 PM
Replies: 4
Views: 460
Posted By GTSRider
Re: Drivers Side Front Turn Signal bulb Out

Found the post...it is the BCM......what do you think...how did this all happen....is it a faulty BCM .... or was it just doing it's job with a lose connection in the plug ?
Showing results 1 to 25 of 64

 
Forum Jump

All times are GMT -4. The time now is 04:25 AM.

Advanced Forum Search | Advanced Photo Search


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2021, vBulletin Solutions Inc.
SaturnFans.com. The Saturn Enthusiasts Site.